Precautions for replacing diesel generator oil

The diesel generator set lubricating oil exchange cycle time is: 600 hours first or 12 months, 300 hours or 12 months, 150 hours or 12 hours, 400 hours or 12 months, 200 hours or 12 months, 100 hours or 12 hours. Month. 200 hours or 12 months 100 hours or 12 months 50 hours or 12 months.

 Generator-1
We can change the lubricating oil quality and the fuel sulfur content according to the difference, and the lubricating oil exchange cycle can range from 50 to 80 hours. The maximum lubricating oil exchange cycle should not exceed 12 months. If the requirements are more than the following table The long lubricant exchange cycle will definitely allow the lubricant manufacturer to test the oil. The fuel sulfur content is 100% less than 0.5% 0.5~1.0% greater than 1.0%.
Make sure the oil level is between the MIN and MAX marks. When using continuously, check the oil level every 8 hours. Shen Hao! It is dangerous to be close to the running motive or work on the top. Pay attention to the placed parts and the high temperature surface. It is necessary to change the lubricating oil in accordance with the regulations. It is necessary to change the lubricating oil filter while changing the lubricating oil. The detailed operation is as follows.
Wipe the filter mount so that there is a dirt drive when the new filter is installed. Drive the drive to the working temperature. Remove the bottom bolt plug, drain the lubricant, and install with a new gasket. Bottom screw plug. Remove the full flow filter and the bypass filter, and make sure that the seals are not left on the drive.
Fill the filter with oil, apply some oil to the gasket, and screw the filter to the belt by hand until the gasket covers the base, then tighten the half turn. Add the lubricant to the appropriate address. Exceed the MAX mark. Start with the motive, let it run at idle speed, check whether the lubricating oil pressure is normal. Turn off the motive, check if there is any oil leakage around the filter, increase if necessary.

Post time: Jun-26-2021